Steering Control System
Typical Manufacturers
8 manufacturers · 75 models
EMRI
24 ✓ 24 verified- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Rudder Angle Feedback Continuity & Potentiometer WearCheck: Verify potentiometer kit replacement intervals: RFC/RFU systems with sliding contact require replacement every 5 years maximum. RFC360-D Hall sensor versions have 10-year service life minimum. Test analog output signals (±12Vdc, ±15Vdc) from feedback units for noise and drift; confirm no mechanical wear in uni-ball links or belt drives on RFU/RFB units.
- Area: Steering Response Time & Servo Control Unit PerformanceCheck: Verify port-to-starboard rudder movement completes within 28-38 seconds per SOLAS requirements. Test RCU servo boxes (RCU10-440, RCU20-440, RCW10-440) for proportional/bang-bang control accuracy. Confirm power supply voltages at KSA control boards are stable (+/-12Vdc, +/-15Vdc, 100Vac). Check no hydraulic lock alarms on torque motors; verify coupling condition.
- Area: WMS PLC System Integrity & Redundancy ConfigurationCheck: Verify WMS (Work Mode Station) PLC firmware version matches documented baseline. Test RSR relay expansion boxes function correctly in multi-rudder systems. Confirm backup power supply (SAB.10/SAB10-230) voltage levels and capacitor condition. Verify hot standby redundancy switches operate without glitches; test fail-over response time.
- Area: Bridge & Wheelhouse Indicator Display AccuracyCheck: Test RIB511 and RIF511 rudder angle indicators for calibration accuracy against actual rudder position sensors. Verify analog output (1-0.1mA) continuity from indicators to autopilot control panels. Confirm SEM300 TFT display brightness (800 cd/m²) is within specification and visible from all bridge positions. Check all 4 control panel connections have consistent readouts; verify alarm annunciation.
- Area: System Compatibility with Steering Gear Brands & Hydraulic ConfigurationCheck: Identify installed steering gear brand (Mitsubishi, Kawasaki, ABB, Hatlapa, Hitachi) and confirm correct RCU/ACU model variant is installed. Verify hydraulic pump configuration matches system design: 3-pump systems use RCU10/RCW10 models, 4-pump LNG systems use RCU20-440. Test proportional vs. bang-bang control mode operation per gear manufacturer specifications. Inspect hydraulic hose condition and pressure relief valve settings.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
Kongsberg
17 ✓ 12 verified- Network communication loss
- Sensor signal drift
- Alarm system fault
- Area: Hydraulic System Pressure and Relief Valve FunctionCheck: Verify system pressure relief valve setting (default 75 bar), test pressure limits on all steering gears, inspect shock-relief control valve blocks for proper operation, confirm pressure bypass back to suction tank above threshold pressure
- Area: Hydraulic Fluid Quality and ContaminationCheck: Test hydraulic oil cleanliness per ISO 4406-1999 (maintain 20/18/15 or equivalent NAS 1638/SAE AS 4059 class 9), verify fluid meets DIN 51524 specification, confirm oil temperature limited to 70°C maximum, check for fluid discoloration or signs of water contamination
- Area: Rudder Position Feedback and Control ResponseCheck: Test rudder positioning accuracy for small and large angles, verify feedback signal integration from K-Steering/Autopilot systems, perform synchronization test on dual-rudder vessels, measure response time to helm commands, check for hysteresis in rudder movement
- Area: Internal Leakage and Maneuvering Time PerformanceCheck: Perform frequency-controlled pump internal leakage test (measure overflow collection volume), verify maneuvering time from hard-over to hard-over position, test with vessels lying still in sheltered waters, document all measurements against baseline specifications
- Area: Structural Integrity and Load Transfer (DTS Systems)Check: Inspect direct trunk support pipe integration for cracks or deformation, verify rudder stock torque transmission without excessive radial forces, check headbox and steering gear deck attachment points, confirm no bending moments transferred to steering gear in DTS configuration
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Hydraulic System Pressure and Relief Valve FunctionCheck: Verify system pressure relief valve setting (default 75 bar), test pressure limits on all steering gears, inspect shock-relief control valve blocks for proper operation, confirm pressure bypass back to suction tank above threshold pressure
- Area: Hydraulic Fluid Quality and ContaminationCheck: Test hydraulic oil cleanliness per ISO 4406-1999 (maintain 20/18/15 or equivalent NAS 1638/SAE AS 4059 class 9), verify fluid meets DIN 51524 specification, confirm oil temperature limited to 70°C maximum, check for fluid discoloration or signs of water contamination
- Area: Rudder Position Feedback and Control ResponseCheck: Test rudder positioning accuracy for small and large angles, verify feedback signal integration from K-Steering/Autopilot systems, perform synchronization test on dual-rudder vessels, measure response time to helm commands, check for hysteresis in rudder movement
- Area: Internal Leakage and Maneuvering Time PerformanceCheck: Perform frequency-controlled pump internal leakage test (measure overflow collection volume), verify maneuvering time from hard-over to hard-over position, test with vessels lying still in sheltered waters, document all measurements against baseline specifications
- Area: Structural Integrity and Load Transfer (DTS Systems)Check: Inspect direct trunk support pipe integration for cracks or deformation, verify rudder stock torque transmission without excessive radial forces, check headbox and steering gear deck attachment points, confirm no bending moments transferred to steering gear in DTS configuration
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Hydraulic System Pressure and Relief Valve FunctionCheck: Verify system pressure relief valve setting (default 75 bar), test pressure limits on all steering gears, inspect shock-relief control valve blocks for proper operation, confirm pressure bypass back to suction tank above threshold pressure
- Area: Hydraulic Fluid Quality and ContaminationCheck: Test hydraulic oil cleanliness per ISO 4406-1999 (maintain 20/18/15 or equivalent NAS 1638/SAE AS 4059 class 9), verify fluid meets DIN 51524 specification, confirm oil temperature limited to 70°C maximum, check for fluid discoloration or signs of water contamination
- Area: Rudder Position Feedback and Control ResponseCheck: Test rudder positioning accuracy for small and large angles, verify feedback signal integration from K-Steering/Autopilot systems, perform synchronization test on dual-rudder vessels, measure response time to helm commands, check for hysteresis in rudder movement
- Area: Internal Leakage and Maneuvering Time PerformanceCheck: Perform frequency-controlled pump internal leakage test (measure overflow collection volume), verify maneuvering time from hard-over to hard-over position, test with vessels lying still in sheltered waters, document all measurements against baseline specifications
- Area: Structural Integrity and Load Transfer (DTS Systems)Check: Inspect direct trunk support pipe integration for cracks or deformation, verify rudder stock torque transmission without excessive radial forces, check headbox and steering gear deck attachment points, confirm no bending moments transferred to steering gear in DTS configuration
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Hydraulic System Pressure and Relief Valve FunctionCheck: Verify system pressure relief valve setting (default 75 bar), test pressure limits on all steering gears, inspect shock-relief control valve blocks for proper operation, confirm pressure bypass back to suction tank above threshold pressure
- Area: Hydraulic Fluid Quality and ContaminationCheck: Test hydraulic oil cleanliness per ISO 4406-1999 (maintain 20/18/15 or equivalent NAS 1638/SAE AS 4059 class 9), verify fluid meets DIN 51524 specification, confirm oil temperature limited to 70°C maximum, check for fluid discoloration or signs of water contamination
- Area: Rudder Position Feedback and Control ResponseCheck: Test rudder positioning accuracy for small and large angles, verify feedback signal integration from K-Steering/Autopilot systems, perform synchronization test on dual-rudder vessels, measure response time to helm commands, check for hysteresis in rudder movement
- Area: Internal Leakage and Maneuvering Time PerformanceCheck: Perform frequency-controlled pump internal leakage test (measure overflow collection volume), verify maneuvering time from hard-over to hard-over position, test with vessels lying still in sheltered waters, document all measurements against baseline specifications
- Area: Structural Integrity and Load Transfer (DTS Systems)Check: Inspect direct trunk support pipe integration for cracks or deformation, verify rudder stock torque transmission without excessive radial forces, check headbox and steering gear deck attachment points, confirm no bending moments transferred to steering gear in DTS configuration
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Hydraulic System Pressure and Relief Valve FunctionCheck: Verify system pressure relief valve setting (default 75 bar), test pressure limits on all steering gears, inspect shock-relief control valve blocks for proper operation, confirm pressure bypass back to suction tank above threshold pressure
- Area: Hydraulic Fluid Quality and ContaminationCheck: Test hydraulic oil cleanliness per ISO 4406-1999 (maintain 20/18/15 or equivalent NAS 1638/SAE AS 4059 class 9), verify fluid meets DIN 51524 specification, confirm oil temperature limited to 70°C maximum, check for fluid discoloration or signs of water contamination
- Area: Rudder Position Feedback and Control ResponseCheck: Test rudder positioning accuracy for small and large angles, verify feedback signal integration from K-Steering/Autopilot systems, perform synchronization test on dual-rudder vessels, measure response time to helm commands, check for hysteresis in rudder movement
- Area: Internal Leakage and Maneuvering Time PerformanceCheck: Perform frequency-controlled pump internal leakage test (measure overflow collection volume), verify maneuvering time from hard-over to hard-over position, test with vessels lying still in sheltered waters, document all measurements against baseline specifications
- Area: Structural Integrity and Load Transfer (DTS Systems)Check: Inspect direct trunk support pipe integration for cracks or deformation, verify rudder stock torque transmission without excessive radial forces, check headbox and steering gear deck attachment points, confirm no bending moments transferred to steering gear in DTS configuration
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Hydraulic System Pressure and Relief Valve FunctionCheck: Verify system pressure relief valve setting (default 75 bar), test pressure limits on all steering gears, inspect shock-relief control valve blocks for proper operation, confirm pressure bypass back to suction tank above threshold pressure
- Area: Hydraulic Fluid Quality and ContaminationCheck: Test hydraulic oil cleanliness per ISO 4406-1999 (maintain 20/18/15 or equivalent NAS 1638/SAE AS 4059 class 9), verify fluid meets DIN 51524 specification, confirm oil temperature limited to 70°C maximum, check for fluid discoloration or signs of water contamination
- Area: Rudder Position Feedback and Control ResponseCheck: Test rudder positioning accuracy for small and large angles, verify feedback signal integration from K-Steering/Autopilot systems, perform synchronization test on dual-rudder vessels, measure response time to helm commands, check for hysteresis in rudder movement
- Area: Internal Leakage and Maneuvering Time PerformanceCheck: Perform frequency-controlled pump internal leakage test (measure overflow collection volume), verify maneuvering time from hard-over to hard-over position, test with vessels lying still in sheltered waters, document all measurements against baseline specifications
- Area: Structural Integrity and Load Transfer (DTS Systems)Check: Inspect direct trunk support pipe integration for cracks or deformation, verify rudder stock torque transmission without excessive radial forces, check headbox and steering gear deck attachment points, confirm no bending moments transferred to steering gear in DTS configuration
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Hydraulic System Pressure and Relief Valve FunctionCheck: Verify system pressure relief valve setting (default 75 bar), test pressure limits on all steering gears, inspect shock-relief control valve blocks for proper operation, confirm pressure bypass back to suction tank above threshold pressure
- Area: Hydraulic Fluid Quality and ContaminationCheck: Test hydraulic oil cleanliness per ISO 4406-1999 (maintain 20/18/15 or equivalent NAS 1638/SAE AS 4059 class 9), verify fluid meets DIN 51524 specification, confirm oil temperature limited to 70°C maximum, check for fluid discoloration or signs of water contamination
- Area: Rudder Position Feedback and Control ResponseCheck: Test rudder positioning accuracy for small and large angles, verify feedback signal integration from K-Steering/Autopilot systems, perform synchronization test on dual-rudder vessels, measure response time to helm commands, check for hysteresis in rudder movement
- Area: Internal Leakage and Maneuvering Time PerformanceCheck: Perform frequency-controlled pump internal leakage test (measure overflow collection volume), verify maneuvering time from hard-over to hard-over position, test with vessels lying still in sheltered waters, document all measurements against baseline specifications
- Area: Structural Integrity and Load Transfer (DTS Systems)Check: Inspect direct trunk support pipe integration for cracks or deformation, verify rudder stock torque transmission without excessive radial forces, check headbox and steering gear deck attachment points, confirm no bending moments transferred to steering gear in DTS configuration
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Hydraulic System Pressure and Relief Valve FunctionCheck: Verify system pressure relief valve setting (default 75 bar), test pressure limits on all steering gears, inspect shock-relief control valve blocks for proper operation, confirm pressure bypass back to suction tank above threshold pressure
- Area: Hydraulic Fluid Quality and ContaminationCheck: Test hydraulic oil cleanliness per ISO 4406-1999 (maintain 20/18/15 or equivalent NAS 1638/SAE AS 4059 class 9), verify fluid meets DIN 51524 specification, confirm oil temperature limited to 70°C maximum, check for fluid discoloration or signs of water contamination
- Area: Rudder Position Feedback and Control ResponseCheck: Test rudder positioning accuracy for small and large angles, verify feedback signal integration from K-Steering/Autopilot systems, perform synchronization test on dual-rudder vessels, measure response time to helm commands, check for hysteresis in rudder movement
- Area: Internal Leakage and Maneuvering Time PerformanceCheck: Perform frequency-controlled pump internal leakage test (measure overflow collection volume), verify maneuvering time from hard-over to hard-over position, test with vessels lying still in sheltered waters, document all measurements against baseline specifications
- Area: Structural Integrity and Load Transfer (DTS Systems)Check: Inspect direct trunk support pipe integration for cracks or deformation, verify rudder stock torque transmission without excessive radial forces, check headbox and steering gear deck attachment points, confirm no bending moments transferred to steering gear in DTS configuration
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Hydraulic System Pressure and Relief Valve FunctionCheck: Verify system pressure relief valve setting (default 75 bar), test pressure limits on all steering gears, inspect shock-relief control valve blocks for proper operation, confirm pressure bypass back to suction tank above threshold pressure
- Area: Hydraulic Fluid Quality and ContaminationCheck: Test hydraulic oil cleanliness per ISO 4406-1999 (maintain 20/18/15 or equivalent NAS 1638/SAE AS 4059 class 9), verify fluid meets DIN 51524 specification, confirm oil temperature limited to 70°C maximum, check for fluid discoloration or signs of water contamination
- Area: Rudder Position Feedback and Control ResponseCheck: Test rudder positioning accuracy for small and large angles, verify feedback signal integration from K-Steering/Autopilot systems, perform synchronization test on dual-rudder vessels, measure response time to helm commands, check for hysteresis in rudder movement
- Area: Internal Leakage and Maneuvering Time PerformanceCheck: Perform frequency-controlled pump internal leakage test (measure overflow collection volume), verify maneuvering time from hard-over to hard-over position, test with vessels lying still in sheltered waters, document all measurements against baseline specifications
- Area: Structural Integrity and Load Transfer (DTS Systems)Check: Inspect direct trunk support pipe integration for cracks or deformation, verify rudder stock torque transmission without excessive radial forces, check headbox and steering gear deck attachment points, confirm no bending moments transferred to steering gear in DTS configuration
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Hydraulic System Pressure and Relief Valve FunctionCheck: Verify system pressure relief valve setting (default 75 bar), test pressure limits on all steering gears, inspect shock-relief control valve blocks for proper operation, confirm pressure bypass back to suction tank above threshold pressure
- Area: Hydraulic Fluid Quality and ContaminationCheck: Test hydraulic oil cleanliness per ISO 4406-1999 (maintain 20/18/15 or equivalent NAS 1638/SAE AS 4059 class 9), verify fluid meets DIN 51524 specification, confirm oil temperature limited to 70°C maximum, check for fluid discoloration or signs of water contamination
- Area: Rudder Position Feedback and Control ResponseCheck: Test rudder positioning accuracy for small and large angles, verify feedback signal integration from K-Steering/Autopilot systems, perform synchronization test on dual-rudder vessels, measure response time to helm commands, check for hysteresis in rudder movement
- Area: Internal Leakage and Maneuvering Time PerformanceCheck: Perform frequency-controlled pump internal leakage test (measure overflow collection volume), verify maneuvering time from hard-over to hard-over position, test with vessels lying still in sheltered waters, document all measurements against baseline specifications
- Area: Structural Integrity and Load Transfer (DTS Systems)Check: Inspect direct trunk support pipe integration for cracks or deformation, verify rudder stock torque transmission without excessive radial forces, check headbox and steering gear deck attachment points, confirm no bending moments transferred to steering gear in DTS configuration
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Hydraulic System Pressure and Relief Valve FunctionCheck: Verify system pressure relief valve setting (default 75 bar), test pressure limits on all steering gears, inspect shock-relief control valve blocks for proper operation, confirm pressure bypass back to suction tank above threshold pressure
- Area: Hydraulic Fluid Quality and ContaminationCheck: Test hydraulic oil cleanliness per ISO 4406-1999 (maintain 20/18/15 or equivalent NAS 1638/SAE AS 4059 class 9), verify fluid meets DIN 51524 specification, confirm oil temperature limited to 70°C maximum, check for fluid discoloration or signs of water contamination
- Area: Rudder Position Feedback and Control ResponseCheck: Test rudder positioning accuracy for small and large angles, verify feedback signal integration from K-Steering/Autopilot systems, perform synchronization test on dual-rudder vessels, measure response time to helm commands, check for hysteresis in rudder movement
- Area: Internal Leakage and Maneuvering Time PerformanceCheck: Perform frequency-controlled pump internal leakage test (measure overflow collection volume), verify maneuvering time from hard-over to hard-over position, test with vessels lying still in sheltered waters, document all measurements against baseline specifications
- Area: Structural Integrity and Load Transfer (DTS Systems)Check: Inspect direct trunk support pipe integration for cracks or deformation, verify rudder stock torque transmission without excessive radial forces, check headbox and steering gear deck attachment points, confirm no bending moments transferred to steering gear in DTS configuration
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Hydraulic System Pressure and Relief Valve FunctionCheck: Verify system pressure relief valve setting (default 75 bar), test pressure limits on all steering gears, inspect shock-relief control valve blocks for proper operation, confirm pressure bypass back to suction tank above threshold pressure
- Area: Hydraulic Fluid Quality and ContaminationCheck: Test hydraulic oil cleanliness per ISO 4406-1999 (maintain 20/18/15 or equivalent NAS 1638/SAE AS 4059 class 9), verify fluid meets DIN 51524 specification, confirm oil temperature limited to 70°C maximum, check for fluid discoloration or signs of water contamination
- Area: Rudder Position Feedback and Control ResponseCheck: Test rudder positioning accuracy for small and large angles, verify feedback signal integration from K-Steering/Autopilot systems, perform synchronization test on dual-rudder vessels, measure response time to helm commands, check for hysteresis in rudder movement
- Area: Internal Leakage and Maneuvering Time PerformanceCheck: Perform frequency-controlled pump internal leakage test (measure overflow collection volume), verify maneuvering time from hard-over to hard-over position, test with vessels lying still in sheltered waters, document all measurements against baseline specifications
- Area: Structural Integrity and Load Transfer (DTS Systems)Check: Inspect direct trunk support pipe integration for cracks or deformation, verify rudder stock torque transmission without excessive radial forces, check headbox and steering gear deck attachment points, confirm no bending moments transferred to steering gear in DTS configuration
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Flügeldichtung-Leckage bei Rotary-Vane-Typ verursacht internen Bypass
- HPU-Motor-Lagerschaden nach 30.000+ Stunden
- Magnetventil-Klemmen durch Öl-Verunreinigung
- Ruderlage-Rückmeldesystem Kalibrierungsdrift
- Flügeldichtung-Leckage bei Rotary-Vane-Typ verursacht internen Bypass
- HPU-Motor-Lagerschaden nach 30.000+ Stunden
- Magnetventil-Klemmen durch Öl-Verunreinigung
- Ruderlage-Rückmeldesystem Kalibrierungsdrift
- Flügeldichtung-Leckage bei Rotary-Vane-Typ verursacht internen Bypass
- HPU-Motor-Lagerschaden nach 30.000+ Stunden
- Magnetventil-Klemmen durch Öl-Verunreinigung
- Ruderlage-Rückmeldesystem Kalibrierungsdrift
- Flügeldichtung-Leckage bei Rotary-Vane-Typ verursacht internen Bypass
- HPU-Motor-Lagerschaden nach 30.000+ Stunden
- Magnetventil-Klemmen durch Öl-Verunreinigung
- Ruderlage-Rückmeldesystem Kalibrierungsdrift
Raytheon Anschütz
15 ✓ 15 verified- Area: CAN-Bus System Redundancy VerificationCheck: Verify dual CAN-bus connections are properly terminated, monitored, and functioning in redundant configuration per IEC 61162-460
- Area: Wire Break Detection and Failsafe OperationCheck: Test wire break alarm function (Type 148-620 device) - confirm 24V monitoring triggers immediately upon disconnection and halts follow-up steering without rudder movement
- Area: Rudder Angle Feedback Signal IntegrityCheck: Measure actual rudder angle using Type 136-065 indicator against command signal; verify ±1° accuracy and <50ms response time per IMO SOLAS requirements
- Area: Proportional Valve Control ResponseCheck: For Type 139-155/159 proportional amplifiers: verify torque motor current, solenoid valve modulation, and time to full rudder deflection (<30 seconds); test at Bridge/Local/Emergency modes
- Area: Steering Stand Electrical Safety and GroundingCheck: ComPilot 20: Verify all pre-wired connections per installation drawings, test earth continuity, confirm 24VDC supply voltage regulation ±10%, and validate emergency steering bypass circuit function
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: CAN-Bus System Redundancy VerificationCheck: Verify dual CAN-bus connections are properly terminated, monitored, and functioning in redundant configuration per IEC 61162-460
- Area: Wire Break Detection and Failsafe OperationCheck: Test wire break alarm function (Type 148-620 device) - confirm 24V monitoring triggers immediately upon disconnection and halts follow-up steering without rudder movement
- Area: Rudder Angle Feedback Signal IntegrityCheck: Measure actual rudder angle using Type 136-065 indicator against command signal; verify ±1° accuracy and <50ms response time per IMO SOLAS requirements
- Area: Proportional Valve Control ResponseCheck: For Type 139-155/159 proportional amplifiers: verify torque motor current, solenoid valve modulation, and time to full rudder deflection (<30 seconds); test at Bridge/Local/Emergency modes
- Area: Steering Stand Electrical Safety and GroundingCheck: ComPilot 20: Verify all pre-wired connections per installation drawings, test earth continuity, confirm 24VDC supply voltage regulation ±10%, and validate emergency steering bypass circuit function
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: CAN-Bus System Redundancy VerificationCheck: Verify dual CAN-bus connections are properly terminated, monitored, and functioning in redundant configuration per IEC 61162-460
- Area: Wire Break Detection and Failsafe OperationCheck: Test wire break alarm function (Type 148-620 device) - confirm 24V monitoring triggers immediately upon disconnection and halts follow-up steering without rudder movement
- Area: Rudder Angle Feedback Signal IntegrityCheck: Measure actual rudder angle using Type 136-065 indicator against command signal; verify ±1° accuracy and <50ms response time per IMO SOLAS requirements
- Area: Proportional Valve Control ResponseCheck: For Type 139-155/159 proportional amplifiers: verify torque motor current, solenoid valve modulation, and time to full rudder deflection (<30 seconds); test at Bridge/Local/Emergency modes
- Area: Steering Stand Electrical Safety and GroundingCheck: ComPilot 20: Verify all pre-wired connections per installation drawings, test earth continuity, confirm 24VDC supply voltage regulation ±10%, and validate emergency steering bypass circuit function
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: CAN-Bus System Redundancy VerificationCheck: Verify dual CAN-bus connections are properly terminated, monitored, and functioning in redundant configuration per IEC 61162-460
- Area: Wire Break Detection and Failsafe OperationCheck: Test wire break alarm function (Type 148-620 device) - confirm 24V monitoring triggers immediately upon disconnection and halts follow-up steering without rudder movement
- Area: Rudder Angle Feedback Signal IntegrityCheck: Measure actual rudder angle using Type 136-065 indicator against command signal; verify ±1° accuracy and <50ms response time per IMO SOLAS requirements
- Area: Proportional Valve Control ResponseCheck: For Type 139-155/159 proportional amplifiers: verify torque motor current, solenoid valve modulation, and time to full rudder deflection (<30 seconds); test at Bridge/Local/Emergency modes
- Area: Steering Stand Electrical Safety and GroundingCheck: ComPilot 20: Verify all pre-wired connections per installation drawings, test earth continuity, confirm 24VDC supply voltage regulation ±10%, and validate emergency steering bypass circuit function
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: CAN-Bus System Redundancy VerificationCheck: Verify dual CAN-bus connections are properly terminated, monitored, and functioning in redundant configuration per IEC 61162-460
- Area: Wire Break Detection and Failsafe OperationCheck: Test wire break alarm function (Type 148-620 device) - confirm 24V monitoring triggers immediately upon disconnection and halts follow-up steering without rudder movement
- Area: Rudder Angle Feedback Signal IntegrityCheck: Measure actual rudder angle using Type 136-065 indicator against command signal; verify ±1° accuracy and <50ms response time per IMO SOLAS requirements
- Area: Proportional Valve Control ResponseCheck: For Type 139-155/159 proportional amplifiers: verify torque motor current, solenoid valve modulation, and time to full rudder deflection (<30 seconds); test at Bridge/Local/Emergency modes
- Area: Steering Stand Electrical Safety and GroundingCheck: ComPilot 20: Verify all pre-wired connections per installation drawings, test earth continuity, confirm 24VDC supply voltage regulation ±10%, and validate emergency steering bypass circuit function
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: CAN-Bus System Redundancy VerificationCheck: Verify dual CAN-bus connections are properly terminated, monitored, and functioning in redundant configuration per IEC 61162-460
- Area: Wire Break Detection and Failsafe OperationCheck: Test wire break alarm function (Type 148-620 device) - confirm 24V monitoring triggers immediately upon disconnection and halts follow-up steering without rudder movement
- Area: Rudder Angle Feedback Signal IntegrityCheck: Measure actual rudder angle using Type 136-065 indicator against command signal; verify ±1° accuracy and <50ms response time per IMO SOLAS requirements
- Area: Proportional Valve Control ResponseCheck: For Type 139-155/159 proportional amplifiers: verify torque motor current, solenoid valve modulation, and time to full rudder deflection (<30 seconds); test at Bridge/Local/Emergency modes
- Area: Steering Stand Electrical Safety and GroundingCheck: ComPilot 20: Verify all pre-wired connections per installation drawings, test earth continuity, confirm 24VDC supply voltage regulation ±10%, and validate emergency steering bypass circuit function
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: CAN-Bus System Redundancy VerificationCheck: Verify dual CAN-bus connections are properly terminated, monitored, and functioning in redundant configuration per IEC 61162-460
- Area: Wire Break Detection and Failsafe OperationCheck: Test wire break alarm function (Type 148-620 device) - confirm 24V monitoring triggers immediately upon disconnection and halts follow-up steering without rudder movement
- Area: Rudder Angle Feedback Signal IntegrityCheck: Measure actual rudder angle using Type 136-065 indicator against command signal; verify ±1° accuracy and <50ms response time per IMO SOLAS requirements
- Area: Proportional Valve Control ResponseCheck: For Type 139-155/159 proportional amplifiers: verify torque motor current, solenoid valve modulation, and time to full rudder deflection (<30 seconds); test at Bridge/Local/Emergency modes
- Area: Steering Stand Electrical Safety and GroundingCheck: ComPilot 20: Verify all pre-wired connections per installation drawings, test earth continuity, confirm 24VDC supply voltage regulation ±10%, and validate emergency steering bypass circuit function
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: CAN-Bus System Redundancy VerificationCheck: Verify dual CAN-bus connections are properly terminated, monitored, and functioning in redundant configuration per IEC 61162-460
- Area: Wire Break Detection and Failsafe OperationCheck: Test wire break alarm function (Type 148-620 device) - confirm 24V monitoring triggers immediately upon disconnection and halts follow-up steering without rudder movement
- Area: Rudder Angle Feedback Signal IntegrityCheck: Measure actual rudder angle using Type 136-065 indicator against command signal; verify ±1° accuracy and <50ms response time per IMO SOLAS requirements
- Area: Proportional Valve Control ResponseCheck: For Type 139-155/159 proportional amplifiers: verify torque motor current, solenoid valve modulation, and time to full rudder deflection (<30 seconds); test at Bridge/Local/Emergency modes
- Area: Steering Stand Electrical Safety and GroundingCheck: ComPilot 20: Verify all pre-wired connections per installation drawings, test earth continuity, confirm 24VDC supply voltage regulation ±10%, and validate emergency steering bypass circuit function
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: CAN-Bus System Redundancy VerificationCheck: Verify dual CAN-bus connections are properly terminated, monitored, and functioning in redundant configuration per IEC 61162-460
- Area: Wire Break Detection and Failsafe OperationCheck: Test wire break alarm function (Type 148-620 device) - confirm 24V monitoring triggers immediately upon disconnection and halts follow-up steering without rudder movement
- Area: Rudder Angle Feedback Signal IntegrityCheck: Measure actual rudder angle using Type 136-065 indicator against command signal; verify ±1° accuracy and <50ms response time per IMO SOLAS requirements
- Area: Proportional Valve Control ResponseCheck: For Type 139-155/159 proportional amplifiers: verify torque motor current, solenoid valve modulation, and time to full rudder deflection (<30 seconds); test at Bridge/Local/Emergency modes
- Area: Steering Stand Electrical Safety and GroundingCheck: ComPilot 20: Verify all pre-wired connections per installation drawings, test earth continuity, confirm 24VDC supply voltage regulation ±10%, and validate emergency steering bypass circuit function
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: CAN-Bus System Redundancy VerificationCheck: Verify dual CAN-bus connections are properly terminated, monitored, and functioning in redundant configuration per IEC 61162-460
- Area: Wire Break Detection and Failsafe OperationCheck: Test wire break alarm function (Type 148-620 device) - confirm 24V monitoring triggers immediately upon disconnection and halts follow-up steering without rudder movement
- Area: Rudder Angle Feedback Signal IntegrityCheck: Measure actual rudder angle using Type 136-065 indicator against command signal; verify ±1° accuracy and <50ms response time per IMO SOLAS requirements
- Area: Proportional Valve Control ResponseCheck: For Type 139-155/159 proportional amplifiers: verify torque motor current, solenoid valve modulation, and time to full rudder deflection (<30 seconds); test at Bridge/Local/Emergency modes
- Area: Steering Stand Electrical Safety and GroundingCheck: ComPilot 20: Verify all pre-wired connections per installation drawings, test earth continuity, confirm 24VDC supply voltage regulation ±10%, and validate emergency steering bypass circuit function
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: CAN-Bus System Redundancy VerificationCheck: Verify dual CAN-bus connections are properly terminated, monitored, and functioning in redundant configuration per IEC 61162-460
- Area: Wire Break Detection and Failsafe OperationCheck: Test wire break alarm function (Type 148-620 device) - confirm 24V monitoring triggers immediately upon disconnection and halts follow-up steering without rudder movement
- Area: Rudder Angle Feedback Signal IntegrityCheck: Measure actual rudder angle using Type 136-065 indicator against command signal; verify ±1° accuracy and <50ms response time per IMO SOLAS requirements
- Area: Proportional Valve Control ResponseCheck: For Type 139-155/159 proportional amplifiers: verify torque motor current, solenoid valve modulation, and time to full rudder deflection (<30 seconds); test at Bridge/Local/Emergency modes
- Area: Steering Stand Electrical Safety and GroundingCheck: ComPilot 20: Verify all pre-wired connections per installation drawings, test earth continuity, confirm 24VDC supply voltage regulation ±10%, and validate emergency steering bypass circuit function
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: CAN-Bus System Redundancy VerificationCheck: Verify dual CAN-bus connections are properly terminated, monitored, and functioning in redundant configuration per IEC 61162-460
- Area: Wire Break Detection and Failsafe OperationCheck: Test wire break alarm function (Type 148-620 device) - confirm 24V monitoring triggers immediately upon disconnection and halts follow-up steering without rudder movement
- Area: Rudder Angle Feedback Signal IntegrityCheck: Measure actual rudder angle using Type 136-065 indicator against command signal; verify ±1° accuracy and <50ms response time per IMO SOLAS requirements
- Area: Proportional Valve Control ResponseCheck: For Type 139-155/159 proportional amplifiers: verify torque motor current, solenoid valve modulation, and time to full rudder deflection (<30 seconds); test at Bridge/Local/Emergency modes
- Area: Steering Stand Electrical Safety and GroundingCheck: ComPilot 20: Verify all pre-wired connections per installation drawings, test earth continuity, confirm 24VDC supply voltage regulation ±10%, and validate emergency steering bypass circuit function
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: CAN-Bus System Redundancy VerificationCheck: Verify dual CAN-bus connections are properly terminated, monitored, and functioning in redundant configuration per IEC 61162-460
- Area: Wire Break Detection and Failsafe OperationCheck: Test wire break alarm function (Type 148-620 device) - confirm 24V monitoring triggers immediately upon disconnection and halts follow-up steering without rudder movement
- Area: Rudder Angle Feedback Signal IntegrityCheck: Measure actual rudder angle using Type 136-065 indicator against command signal; verify ±1° accuracy and <50ms response time per IMO SOLAS requirements
- Area: Proportional Valve Control ResponseCheck: For Type 139-155/159 proportional amplifiers: verify torque motor current, solenoid valve modulation, and time to full rudder deflection (<30 seconds); test at Bridge/Local/Emergency modes
- Area: Steering Stand Electrical Safety and GroundingCheck: ComPilot 20: Verify all pre-wired connections per installation drawings, test earth continuity, confirm 24VDC supply voltage regulation ±10%, and validate emergency steering bypass circuit function
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: CAN-Bus System Redundancy VerificationCheck: Verify dual CAN-bus connections are properly terminated, monitored, and functioning in redundant configuration per IEC 61162-460
- Area: Wire Break Detection and Failsafe OperationCheck: Test wire break alarm function (Type 148-620 device) - confirm 24V monitoring triggers immediately upon disconnection and halts follow-up steering without rudder movement
- Area: Rudder Angle Feedback Signal IntegrityCheck: Measure actual rudder angle using Type 136-065 indicator against command signal; verify ±1° accuracy and <50ms response time per IMO SOLAS requirements
- Area: Proportional Valve Control ResponseCheck: For Type 139-155/159 proportional amplifiers: verify torque motor current, solenoid valve modulation, and time to full rudder deflection (<30 seconds); test at Bridge/Local/Emergency modes
- Area: Steering Stand Electrical Safety and GroundingCheck: ComPilot 20: Verify all pre-wired connections per installation drawings, test earth continuity, confirm 24VDC supply voltage regulation ±10%, and validate emergency steering bypass circuit function
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: CAN-Bus System Redundancy VerificationCheck: Verify dual CAN-bus connections are properly terminated, monitored, and functioning in redundant configuration per IEC 61162-460
- Area: Wire Break Detection and Failsafe OperationCheck: Test wire break alarm function (Type 148-620 device) - confirm 24V monitoring triggers immediately upon disconnection and halts follow-up steering without rudder movement
- Area: Rudder Angle Feedback Signal IntegrityCheck: Measure actual rudder angle using Type 136-065 indicator against command signal; verify ±1° accuracy and <50ms response time per IMO SOLAS requirements
- Area: Proportional Valve Control ResponseCheck: For Type 139-155/159 proportional amplifiers: verify torque motor current, solenoid valve modulation, and time to full rudder deflection (<30 seconds); test at Bridge/Local/Emergency modes
- Area: Steering Stand Electrical Safety and GroundingCheck: ComPilot 20: Verify all pre-wired connections per installation drawings, test earth continuity, confirm 24VDC supply voltage regulation ±10%, and validate emergency steering bypass circuit function
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
Yokogawa
13 ✓ 13 verified- Area: Heading indication accuracy and sensor input verificationCheck: Check if heading indication on AP CDU matches steering repeater and alternative heading input sources (if available) once per week. Verify 3-axis heading sensor ports (IEC61162-1/2) are properly connected and synchronized.
- Area: Touch panel and control interface responsivenessCheck: Tap the touch panel periodically and verify correct response to user inputs. Ensure display clarity and no visual defects. Test all autopilot modes (AUTO, HAND, NFU, CRS) for proper control signal transmission.
- Area: Main control unit relay and switching integrityCheck: Verify RL8 relay on MAN TERMINAL baseplate is energized once when selecting NO.1 or NO.2 at system selector. Test once every six months. Check for audible clicks and proper relay engagement.
- Area: Electrical connections and mechanical integrityCheck: Inspect all terminal connections for looseness, corrosion, and oxidation. Retighten fixing screws if loose. Check cable routing for damage, chafing, and proper strain relief. Verify backup 24V DC power supply continuity once every six months.
- Area: Rudder feedback signal and command integrity (IMO SOLAS requirement)Check: Verify rudder angle feedback signal is received and displayed correctly on AP CDU. Test rudder command output to steering actuator (solenoid valve or torque motor) for proper response. Check for MCU (Adaptive) timeouts. Ensure rudder angle matches command within 0.5 degrees.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Heading indication accuracy and sensor input verificationCheck: Check if heading indication on AP CDU matches steering repeater and alternative heading input sources (if available) once per week. Verify 3-axis heading sensor ports (IEC61162-1/2) are properly connected and synchronized.
- Area: Touch panel and control interface responsivenessCheck: Tap the touch panel periodically and verify correct response to user inputs. Ensure display clarity and no visual defects. Test all autopilot modes (AUTO, HAND, NFU, CRS) for proper control signal transmission.
- Area: Main control unit relay and switching integrityCheck: Verify RL8 relay on MAN TERMINAL baseplate is energized once when selecting NO.1 or NO.2 at system selector. Test once every six months. Check for audible clicks and proper relay engagement.
- Area: Electrical connections and mechanical integrityCheck: Inspect all terminal connections for looseness, corrosion, and oxidation. Retighten fixing screws if loose. Check cable routing for damage, chafing, and proper strain relief. Verify backup 24V DC power supply continuity once every six months.
- Area: Rudder feedback signal and command integrity (IMO SOLAS requirement)Check: Verify rudder angle feedback signal is received and displayed correctly on AP CDU. Test rudder command output to steering actuator (solenoid valve or torque motor) for proper response. Check for MCU (Adaptive) timeouts. Ensure rudder angle matches command within 0.5 degrees.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Heading indication accuracy and sensor input verificationCheck: Check if heading indication on AP CDU matches steering repeater and alternative heading input sources (if available) once per week. Verify 3-axis heading sensor ports (IEC61162-1/2) are properly connected and synchronized.
- Area: Touch panel and control interface responsivenessCheck: Tap the touch panel periodically and verify correct response to user inputs. Ensure display clarity and no visual defects. Test all autopilot modes (AUTO, HAND, NFU, CRS) for proper control signal transmission.
- Area: Main control unit relay and switching integrityCheck: Verify RL8 relay on MAN TERMINAL baseplate is energized once when selecting NO.1 or NO.2 at system selector. Test once every six months. Check for audible clicks and proper relay engagement.
- Area: Electrical connections and mechanical integrityCheck: Inspect all terminal connections for looseness, corrosion, and oxidation. Retighten fixing screws if loose. Check cable routing for damage, chafing, and proper strain relief. Verify backup 24V DC power supply continuity once every six months.
- Area: Rudder feedback signal and command integrity (IMO SOLAS requirement)Check: Verify rudder angle feedback signal is received and displayed correctly on AP CDU. Test rudder command output to steering actuator (solenoid valve or torque motor) for proper response. Check for MCU (Adaptive) timeouts. Ensure rudder angle matches command within 0.5 degrees.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Heading indication accuracy and sensor input verificationCheck: Check if heading indication on AP CDU matches steering repeater and alternative heading input sources (if available) once per week. Verify 3-axis heading sensor ports (IEC61162-1/2) are properly connected and synchronized.
- Area: Touch panel and control interface responsivenessCheck: Tap the touch panel periodically and verify correct response to user inputs. Ensure display clarity and no visual defects. Test all autopilot modes (AUTO, HAND, NFU, CRS) for proper control signal transmission.
- Area: Main control unit relay and switching integrityCheck: Verify RL8 relay on MAN TERMINAL baseplate is energized once when selecting NO.1 or NO.2 at system selector. Test once every six months. Check for audible clicks and proper relay engagement.
- Area: Electrical connections and mechanical integrityCheck: Inspect all terminal connections for looseness, corrosion, and oxidation. Retighten fixing screws if loose. Check cable routing for damage, chafing, and proper strain relief. Verify backup 24V DC power supply continuity once every six months.
- Area: Rudder feedback signal and command integrity (IMO SOLAS requirement)Check: Verify rudder angle feedback signal is received and displayed correctly on AP CDU. Test rudder command output to steering actuator (solenoid valve or torque motor) for proper response. Check for MCU (Adaptive) timeouts. Ensure rudder angle matches command within 0.5 degrees.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Heading indication accuracy and sensor input verificationCheck: Check if heading indication on AP CDU matches steering repeater and alternative heading input sources (if available) once per week. Verify 3-axis heading sensor ports (IEC61162-1/2) are properly connected and synchronized.
- Area: Touch panel and control interface responsivenessCheck: Tap the touch panel periodically and verify correct response to user inputs. Ensure display clarity and no visual defects. Test all autopilot modes (AUTO, HAND, NFU, CRS) for proper control signal transmission.
- Area: Main control unit relay and switching integrityCheck: Verify RL8 relay on MAN TERMINAL baseplate is energized once when selecting NO.1 or NO.2 at system selector. Test once every six months. Check for audible clicks and proper relay engagement.
- Area: Electrical connections and mechanical integrityCheck: Inspect all terminal connections for looseness, corrosion, and oxidation. Retighten fixing screws if loose. Check cable routing for damage, chafing, and proper strain relief. Verify backup 24V DC power supply continuity once every six months.
- Area: Rudder feedback signal and command integrity (IMO SOLAS requirement)Check: Verify rudder angle feedback signal is received and displayed correctly on AP CDU. Test rudder command output to steering actuator (solenoid valve or torque motor) for proper response. Check for MCU (Adaptive) timeouts. Ensure rudder angle matches command within 0.5 degrees.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Heading indication accuracy and sensor input verificationCheck: Check if heading indication on AP CDU matches steering repeater and alternative heading input sources (if available) once per week. Verify 3-axis heading sensor ports (IEC61162-1/2) are properly connected and synchronized.
- Area: Touch panel and control interface responsivenessCheck: Tap the touch panel periodically and verify correct response to user inputs. Ensure display clarity and no visual defects. Test all autopilot modes (AUTO, HAND, NFU, CRS) for proper control signal transmission.
- Area: Main control unit relay and switching integrityCheck: Verify RL8 relay on MAN TERMINAL baseplate is energized once when selecting NO.1 or NO.2 at system selector. Test once every six months. Check for audible clicks and proper relay engagement.
- Area: Electrical connections and mechanical integrityCheck: Inspect all terminal connections for looseness, corrosion, and oxidation. Retighten fixing screws if loose. Check cable routing for damage, chafing, and proper strain relief. Verify backup 24V DC power supply continuity once every six months.
- Area: Rudder feedback signal and command integrity (IMO SOLAS requirement)Check: Verify rudder angle feedback signal is received and displayed correctly on AP CDU. Test rudder command output to steering actuator (solenoid valve or torque motor) for proper response. Check for MCU (Adaptive) timeouts. Ensure rudder angle matches command within 0.5 degrees.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Heading indication accuracy and sensor input verificationCheck: Check if heading indication on AP CDU matches steering repeater and alternative heading input sources (if available) once per week. Verify 3-axis heading sensor ports (IEC61162-1/2) are properly connected and synchronized.
- Area: Touch panel and control interface responsivenessCheck: Tap the touch panel periodically and verify correct response to user inputs. Ensure display clarity and no visual defects. Test all autopilot modes (AUTO, HAND, NFU, CRS) for proper control signal transmission.
- Area: Main control unit relay and switching integrityCheck: Verify RL8 relay on MAN TERMINAL baseplate is energized once when selecting NO.1 or NO.2 at system selector. Test once every six months. Check for audible clicks and proper relay engagement.
- Area: Electrical connections and mechanical integrityCheck: Inspect all terminal connections for looseness, corrosion, and oxidation. Retighten fixing screws if loose. Check cable routing for damage, chafing, and proper strain relief. Verify backup 24V DC power supply continuity once every six months.
- Area: Rudder feedback signal and command integrity (IMO SOLAS requirement)Check: Verify rudder angle feedback signal is received and displayed correctly on AP CDU. Test rudder command output to steering actuator (solenoid valve or torque motor) for proper response. Check for MCU (Adaptive) timeouts. Ensure rudder angle matches command within 0.5 degrees.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Heading indication accuracy and sensor input verificationCheck: Check if heading indication on AP CDU matches steering repeater and alternative heading input sources (if available) once per week. Verify 3-axis heading sensor ports (IEC61162-1/2) are properly connected and synchronized.
- Area: Touch panel and control interface responsivenessCheck: Tap the touch panel periodically and verify correct response to user inputs. Ensure display clarity and no visual defects. Test all autopilot modes (AUTO, HAND, NFU, CRS) for proper control signal transmission.
- Area: Main control unit relay and switching integrityCheck: Verify RL8 relay on MAN TERMINAL baseplate is energized once when selecting NO.1 or NO.2 at system selector. Test once every six months. Check for audible clicks and proper relay engagement.
- Area: Electrical connections and mechanical integrityCheck: Inspect all terminal connections for looseness, corrosion, and oxidation. Retighten fixing screws if loose. Check cable routing for damage, chafing, and proper strain relief. Verify backup 24V DC power supply continuity once every six months.
- Area: Rudder feedback signal and command integrity (IMO SOLAS requirement)Check: Verify rudder angle feedback signal is received and displayed correctly on AP CDU. Test rudder command output to steering actuator (solenoid valve or torque motor) for proper response. Check for MCU (Adaptive) timeouts. Ensure rudder angle matches command within 0.5 degrees.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Heading indication accuracy and sensor input verificationCheck: Check if heading indication on AP CDU matches steering repeater and alternative heading input sources (if available) once per week. Verify 3-axis heading sensor ports (IEC61162-1/2) are properly connected and synchronized.
- Area: Touch panel and control interface responsivenessCheck: Tap the touch panel periodically and verify correct response to user inputs. Ensure display clarity and no visual defects. Test all autopilot modes (AUTO, HAND, NFU, CRS) for proper control signal transmission.
- Area: Main control unit relay and switching integrityCheck: Verify RL8 relay on MAN TERMINAL baseplate is energized once when selecting NO.1 or NO.2 at system selector. Test once every six months. Check for audible clicks and proper relay engagement.
- Area: Electrical connections and mechanical integrityCheck: Inspect all terminal connections for looseness, corrosion, and oxidation. Retighten fixing screws if loose. Check cable routing for damage, chafing, and proper strain relief. Verify backup 24V DC power supply continuity once every six months.
- Area: Rudder feedback signal and command integrity (IMO SOLAS requirement)Check: Verify rudder angle feedback signal is received and displayed correctly on AP CDU. Test rudder command output to steering actuator (solenoid valve or torque motor) for proper response. Check for MCU (Adaptive) timeouts. Ensure rudder angle matches command within 0.5 degrees.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Heading indication accuracy and sensor input verificationCheck: Check if heading indication on AP CDU matches steering repeater and alternative heading input sources (if available) once per week. Verify 3-axis heading sensor ports (IEC61162-1/2) are properly connected and synchronized.
- Area: Touch panel and control interface responsivenessCheck: Tap the touch panel periodically and verify correct response to user inputs. Ensure display clarity and no visual defects. Test all autopilot modes (AUTO, HAND, NFU, CRS) for proper control signal transmission.
- Area: Main control unit relay and switching integrityCheck: Verify RL8 relay on MAN TERMINAL baseplate is energized once when selecting NO.1 or NO.2 at system selector. Test once every six months. Check for audible clicks and proper relay engagement.
- Area: Electrical connections and mechanical integrityCheck: Inspect all terminal connections for looseness, corrosion, and oxidation. Retighten fixing screws if loose. Check cable routing for damage, chafing, and proper strain relief. Verify backup 24V DC power supply continuity once every six months.
- Area: Rudder feedback signal and command integrity (IMO SOLAS requirement)Check: Verify rudder angle feedback signal is received and displayed correctly on AP CDU. Test rudder command output to steering actuator (solenoid valve or torque motor) for proper response. Check for MCU (Adaptive) timeouts. Ensure rudder angle matches command within 0.5 degrees.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Heading indication accuracy and sensor input verificationCheck: Check if heading indication on AP CDU matches steering repeater and alternative heading input sources (if available) once per week. Verify 3-axis heading sensor ports (IEC61162-1/2) are properly connected and synchronized.
- Area: Touch panel and control interface responsivenessCheck: Tap the touch panel periodically and verify correct response to user inputs. Ensure display clarity and no visual defects. Test all autopilot modes (AUTO, HAND, NFU, CRS) for proper control signal transmission.
- Area: Main control unit relay and switching integrityCheck: Verify RL8 relay on MAN TERMINAL baseplate is energized once when selecting NO.1 or NO.2 at system selector. Test once every six months. Check for audible clicks and proper relay engagement.
- Area: Electrical connections and mechanical integrityCheck: Inspect all terminal connections for looseness, corrosion, and oxidation. Retighten fixing screws if loose. Check cable routing for damage, chafing, and proper strain relief. Verify backup 24V DC power supply continuity once every six months.
- Area: Rudder feedback signal and command integrity (IMO SOLAS requirement)Check: Verify rudder angle feedback signal is received and displayed correctly on AP CDU. Test rudder command output to steering actuator (solenoid valve or torque motor) for proper response. Check for MCU (Adaptive) timeouts. Ensure rudder angle matches command within 0.5 degrees.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Heading indication accuracy and sensor input verificationCheck: Check if heading indication on AP CDU matches steering repeater and alternative heading input sources (if available) once per week. Verify 3-axis heading sensor ports (IEC61162-1/2) are properly connected and synchronized.
- Area: Touch panel and control interface responsivenessCheck: Tap the touch panel periodically and verify correct response to user inputs. Ensure display clarity and no visual defects. Test all autopilot modes (AUTO, HAND, NFU, CRS) for proper control signal transmission.
- Area: Main control unit relay and switching integrityCheck: Verify RL8 relay on MAN TERMINAL baseplate is energized once when selecting NO.1 or NO.2 at system selector. Test once every six months. Check for audible clicks and proper relay engagement.
- Area: Electrical connections and mechanical integrityCheck: Inspect all terminal connections for looseness, corrosion, and oxidation. Retighten fixing screws if loose. Check cable routing for damage, chafing, and proper strain relief. Verify backup 24V DC power supply continuity once every six months.
- Area: Rudder feedback signal and command integrity (IMO SOLAS requirement)Check: Verify rudder angle feedback signal is received and displayed correctly on AP CDU. Test rudder command output to steering actuator (solenoid valve or torque motor) for proper response. Check for MCU (Adaptive) timeouts. Ensure rudder angle matches command within 0.5 degrees.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
- Area: Heading indication accuracy and sensor input verificationCheck: Check if heading indication on AP CDU matches steering repeater and alternative heading input sources (if available) once per week. Verify 3-axis heading sensor ports (IEC61162-1/2) are properly connected and synchronized.
- Area: Touch panel and control interface responsivenessCheck: Tap the touch panel periodically and verify correct response to user inputs. Ensure display clarity and no visual defects. Test all autopilot modes (AUTO, HAND, NFU, CRS) for proper control signal transmission.
- Area: Main control unit relay and switching integrityCheck: Verify RL8 relay on MAN TERMINAL baseplate is energized once when selecting NO.1 or NO.2 at system selector. Test once every six months. Check for audible clicks and proper relay engagement.
- Area: Electrical connections and mechanical integrityCheck: Inspect all terminal connections for looseness, corrosion, and oxidation. Retighten fixing screws if loose. Check cable routing for damage, chafing, and proper strain relief. Verify backup 24V DC power supply continuity once every six months.
- Area: Rudder feedback signal and command integrity (IMO SOLAS requirement)Check: Verify rudder angle feedback signal is received and displayed correctly on AP CDU. Test rudder command output to steering actuator (solenoid valve or torque motor) for proper response. Check for MCU (Adaptive) timeouts. Ensure rudder angle matches command within 0.5 degrees.
Typ-universelle Inspektionspunkte fuer Steering Gear (verifiziert, 2026-06).
MAN Energy Solutions
3- Flügeldichtung-Leckage bei Rotary-Vane-Typ verursacht internen Bypass
- HPU-Motor-Lagerschaden nach 30.000+ Stunden
- Magnetventil-Klemmen durch Öl-Verunreinigung
- Ruderlage-Rückmeldesystem Kalibrierungsdrift
- Flügeldichtung-Leckage bei Rotary-Vane-Typ verursacht internen Bypass
- HPU-Motor-Lagerschaden nach 30.000+ Stunden
- Magnetventil-Klemmen durch Öl-Verunreinigung
- Ruderlage-Rückmeldesystem Kalibrierungsdrift
- Flügeldichtung-Leckage bei Rotary-Vane-Typ verursacht internen Bypass
- HPU-Motor-Lagerschaden nach 30.000+ Stunden
- Magnetventil-Klemmen durch Öl-Verunreinigung
- Ruderlage-Rückmeldesystem Kalibrierungsdrift
Anschuetz
1- Heading sensor drift
- Autopilot hunting/oscillation
- FU/NFU changeover switch failure
Brunvoll Mar-El
1- Flügeldichtung-Leckage bei Rotary-Vane-Typ verursacht internen Bypass
- HPU-Motor-Lagerschaden nach 30.000+ Stunden
- Magnetventil-Klemmen durch Öl-Verunreinigung
- Ruderlage-Rückmeldesystem Kalibrierungsdrift
Raytheon
1- Potentiometer feedback noise
- Relay contact wear
- Emergency steering handover failure